海洋生物沉积附着对山东荣成黄海水域出水古陶瓷器的腐蚀

doi:10.12066/j.issn.1007-2861.2752

上海大学学报(自然科学版) ›› 2026, Vol. 32 ›› Issue (4): 579-597.doi: 10.12066/j.issn.1007-2861.2752

• 文化遗产保护与考古 • 上一篇

海洋生物沉积附着对山东荣成黄海水域出水古陶瓷器的腐蚀

杨勇¹, 亢雯清², LEE Soobin², 兰栋¹, 陈启明³, 赵静²

1. 山东省水下考古研究中心, 济南 250100;
2. 中国科学院上海硅酸盐研究所, 上海 201800;
3. 上海大学生命科学学院, 上海 200444

收稿日期:2026-05-11 发布日期:2026-09-04
通讯作者: 赵静(1981—),女,正高级工程师,博士,研究方向为文物保护.E-mail:zhaojing@mail.sic.ac.cn E-mail:zhaojing@mail.sic.ac.cn
基金资助:
上海市关键技术研发计划资助项目(25JC3202003)

Corrosion of ancient ceramics recovered from the Yellow Sea waters of Rongcheng city, Shandong Province due to marine biological sedimentation and adhesion

YANG Yong¹, KANG Wenqing², LEE Soobin², LAN Dong¹, CHEN Qiming³, ZHAO Jing²

1. Shandong Provincial Underwater Archaeological Research Center, Jinan 250100, China;
2. Shanghai Institute of Ceramics, Chinese Academy of Sciences, Shanghai 201800, China;
3. School of Life Sciences, Shanghai University, Shanghai 200444, China

Received:2026-05-11 Published:2026-09-04

摘要/Abstract

摘要： 针对海洋生物附着对出水古陶瓷釉层的腐蚀变化,以山东省荣成市所属黄海水域出水古陶瓷样品为研究对象,综合采用微区X射线荧光光谱(μ-X-ray fluorescence spectrometer,m-XRF)、扫描电子显微镜(scanning electron microscope,SEM)-能量色散光谱(energy dispersive spectroscope,EDS)、X射线衍射(X-ray diffraction,XRD)、X射线光电子能谱(X-ray photoelectron spectroscope,XPS)、热裂解-气相色谱-质谱(pyrolysis-gas chromatography-mass spectrometry,PY-GC/MS)及微生物测序等技术,系统分析了苔藓虫、盘管虫和牡蛎等生物沉积附着对陶瓷釉层的腐蚀特性.结果表明:苔藓虫附着在古陶瓷器表面呈点式密集分布,粘结区域附着明显的有机蛋白胶结质,呈现黑色,且主要成分为Fe/Mn氧化物的腐蚀质;牡蛎附着在古陶瓷器粗糙表面,且分布有大量孢子状含C物质;盘管虫粘结面呈条带状且内部为鳞片状,其附着区域伴随有大量硅藻,并在古陶瓷器表面形成了由羟基氧化铁(FeO (OH))组成的黑色腐蚀产物;古陶瓷器表面附着代尔夫特菌属(Delftia)和假单胞菌属(Pseudomonas)等微生物;腐蚀区域含有生物蛋白胶结质的丙氨酸、甘氨酸,以及经过微生物降解后产生的硬脂酸甲酯等.这些结果进一步确定了海洋微生物及其代谢和降解对古陶瓷器表面生物沉积的腐蚀影响,为海洋生物沉积物对出水古陶瓷器的界面腐蚀提供了重要的科学依据.

关键词: 黄海水域, 出水古陶瓷, 生物沉积, 腐蚀机制

Abstract: This study aimed to investigate the corrosion of glaze layers on ancient ceramics recovered from waters under the influence of marine biofouling. Taking the ancient ceramic samples recovered from the Yellow Sea waters of Rongcheng City, Shandong Province as the research objects, the study analyzed the characteristics of corrosion on the ceramic glaze layers due to the biological sedimentation and adhesion of bryozoans, hydroides, oysters, etc. It was employed m-X-ray fluorescence spectrometer (m-XRF), scanning electron microscope (SEM)-energy dispersive spectroscope (EDS), X-ray diffraction (XRD), X-ray photoelectron spectroscope (XPS), pyrolysis-gas chromatography-mass spectrometry (PY-GC/MS), and microbial sequencing. The results showed that bryozoans densely colonized the ceramic surfaces in a punctate pattern. At attachment sites, organic proteinaceous cements were present, appearing black in color, with the corrosive material primarily composed of Fe/Mn oxides. Oysters adhered preferentially to roughened ceramic areas and were associated with abundant spore-like carbonaceous particles. Hydroides exhibited a striated external morphology and internal scale-like structures at the interface, with the attachment zones being rich in diatoms, which contributed to the formation of black corrosion products composed primarily of FeO(OH). Microbial communities such as Delftia and Pseudomonas were detected on the ceramic surfaces. Furthermore, the corrosion areas contained alanine and glycine derived from proteinaceous cements, as well as methyl stearate produced through microbial degradation. These findings further confirmed the corrosive effects of marine microorganisms, as well as their metabolism and degradation, on biological sedimentation on ceramic surfaces. The results provided important scientific evidences for understanding marine-biofouling-induced interfacial corrosion of recovered ceramics from waters.

Key words: Yellow Sea waters, recovered ancient ceramics from waters, biological sedimentation, corrosion mechanism

中图分类号:

K854

杨勇, 亢雯清, LEE Soobin, 兰栋, 陈启明, 赵静. 海洋生物沉积附着对山东荣成黄海水域出水古陶瓷器的腐蚀[J]. 上海大学学报(自然科学版), 2026, 32(4): 579-597.

YANG Yong, KANG Wenqing, LEE Soobin, LAN Dong, CHEN Qiming, ZHAO Jing. Corrosion of ancient ceramics recovered from the Yellow Sea waters of Rongcheng city, Shandong Province due to marine biological sedimentation and adhesion[J]. Journal of Shanghai University（Natural Science Edition）, 2026, 32(4): 579-597.

[1] 何琰, 李伟东, 翟杨, 等. "长江口二号" 沉船出水青花瓷中的污染物研究[J]. 文物保护与考古科学, 2023, 35(5): 1-16.
[2] Hao X L, Zhu T Q, Xu J J, et al. Microscopic study on the concretion of ceramics in the "Nanhai I" shipwreck of China, Southern Song Dynasty (1127—1279 A. D.) [J]. Microsc Res Tech, 2018, 81(5): 486-493.
[3] Ding R, Li W D, Yang Z, et al. Degradation mechanism of a sauce-glazed ware of the Song Dynasty salvaged out of the water at Dalian Island Wharf, Part I: the Effect of the surfaceattached composite coagula [J]. Mater, 2023, 16(3): 1176-1198.
[4] Ricca M, Cáamara B, Fort R, et al. Definition of analytical cleaning procedures for archaeological pottery from underwater environments: the case study of samples from Baia (Naples, South Italy) [J]. Mater Des, 2021, 187: 109278-109290.
[5] Ding R, Li W D, Yang Z L, et al. Degradation of a sauce-glazed ware from the Song Dynasty salvaged out of water at the Dalian Island Wharf, Part II: the Effect of the surface-attached marine organism remains [J]. Appl Sci, 2024, 14: 1-24.
[6] 包春磊, 贾世杰, 符燕, 等. "华光礁I号" 沉船出水青白瓷表面沉积物的分析[J]. 化学研究, 2014, 25(1): 76-81.
[7] 刘晓清. "南澳I号" 出水瓷器文物凝结物类型研究[J]. 福建文博, 2021, 2: 51-58.
[8] 张欢. "南澳I号" 沉船出水瓷器类文物表面凝结物激光清洗实验研究[J]. 中国文化遗产, 2019(5): 85-90.
[9] 张治国, 刘婕, 李乃胜, 等. "南澳I号" 沉船出水凝结物的整体保护[J]. 文物保护与考古科学, 2019, 31(4): 1-9.
[10] Casaletto M P, Ingo G M, Riccucci C, et al. Chemical cleaning of encrustations on archaeological ceramic artefacts found in different Italian sites [J]. Phys A, 2008, 92(1): 35- 42.
[11] 毛洪丽, 刘雨, 张建国. 荧光蛋白及其在微生物过程工程中的应用[J]. 食品与发酵工业, 2019, 45(17): 252-257.
[12] Diellza B, Agustina S, Victor M L, et al. Rapid discrimination of Lentilactobacillus parabuchneri biofilms via in situ infrared spectroscopy [J]. Spectrochimica Acta Part A: Molecular and Biomolecular Spectroscopy, 2024, 304: 1-19.
[13] Potter R M, Rossman G R. Mineralogy of manganese dendrites and coatings [J]. AM Mineral, 1979, 64(11/12): 1219-1226.
[14] Currie L A, Loebenstein H V, Deitz V R. Infrared spectrophotometric analysis of minerals: carbonates [J]. Appl Spectrosc, 1978, 32(1): 45-48.
[15] Addadi L, Raz S, Weiner S. Taking advantage of disorder: amorphous calcium carbonate and its roles in biomineralization [J]. Adv Mater, 2006, 18(8): 995-1000.
[16] 周卜, 袁华茂, 宋金明, 等. 海洋颗粒物/沉积物中的氨基酸及其对有机质降解的指示作用[J]. 应用生态学报, 2018, 29(9): 3147-3158.
[17] Das S, Rodriguez N R M, Wei W, et al. Peptide length and dopa determine iron-mediated cohesion of mussel foot proteins [J]. Adv Funct Mater, 2015, 25: 5840-5847.
[18] 谢林, 曹为, 蒋凤华. 印度洋深海热液区贻贝足丝结构和性能特征研究[J]. 海洋与湖沼, 2022, 53(2): 364-374.
[19] Jaeger K E, Eggert T. Lipases for biotechnology [J]. Curr Opin Biotechnol, 2002, 13(4): 390-397.
[20] Joergensen R G. Phospholipid fatty acids in soil: drawbacks and future prospects [J]. Biol Fertil Soils, 2022, 58: 1-6.
[21] Yang S, Xu Z W, Wang R Z, et al. Variations in soil microbial community composition and enzymatic activities in response to increased N deposition and precipitation in Inner Mongolian grassland [J]. Applied Soil Ecology, 2017, 119: 275-285.
[22] Li Q Z, Shi M, Liao Q, et al. Molecular response to the influences of Cu(II) and Fe(III) on forming biogenic manganese oxides by Pseudomonas putida MnB1[J]. Hazard Mater, 2024, 477: 135298-135310.
[23] Matthew C S, Ajeet M, Amar M, et al. A novel technique using potassium permanganate and reflectance confocal microscopy to image biofilm extracellular polymeric matrix reveals noneDNA networks in Pseudomonas aeruginosa biofilms [J]. Pathogens and Disease, 2016, 74(1): 104-116.
[24] Chang J, Tian L, Leite M, et al. Nitrogen, manganese, iron, and carbon resource acquisition are potential functions of the wild rice Oryza rufipogon core rhizomicrobiome [J]. Microbiome, 2022, 10: 196-206.
[25] Tom H, Bart D G, Nico B, et al. Biogenic metals in advanced water treatment [J]. Trends Biotechnol, 2009, 27: 90-98.
[26] 吴川, 罗雨轩, 薛生国, 等. 铁/锰氧化菌诱导土壤重金属生物成矿研究进展[J]. 土壤学报, 2023, 60(4): 953-968.
[27] Hu X M, Peng L H, Wu J X, et al. Bacterial c-di-GMP signaling gene afiects mussel larval metamorphosis through outer membrane vesicles and lipopolysaccharides [J]. NPJ biofilms Microbi, 2024, 10: 1-12.
[28] Decker S H, Lemer S, Decker S, et al. Boring life: early colony formation and growth in the endolithic bryozoan genus Penetrantia Siláen, 1946[J]. Zool Lett, 2024, 10: 1-18.
[29] Karrie A W, Laurie A A, John D C. Microorganisms pumping iron: anaerobic microbial iron oxidation and reduction [J]. Nat Rev Microbiol, 2006, 4: 752-764.
[30] Yu H, Leadbetter J R. Bacterial chemolithoautotrophy via manganese oxidation [J]. Nature, 2020, 583: 453-458.

海洋生物沉积附着对山东荣成黄海水域出水古陶瓷器的腐蚀

Corrosion of ancient ceramics recovered from the Yellow Sea waters of Rongcheng city, Shandong Province due to marine biological sedimentation and adhesion

PDF

可视化

摘要/Abstract

引用本文

使用本文

相关文章 0

编辑推荐

Metrics

本文评价