English

上海大学学报(自然科学版) ›› 2015, Vol. 21 ›› Issue (6): 701-708.doi: 10.3969/j.issn.1007-2861.2014.03.009

• 环境与化学工程 • 上一篇    下一篇

氨法脱硫中亚硫酸铵的氧化工艺参数

 顾晓婧, 何仁初, 万皓, 范向东   

  1. 1. 上海大学机电工程与自动化学院, 上海200072; 2 上海大学环境与化学工程学院, 上海200444
  • 收稿日期:2014-05-09 出版日期:2015-12-29 发布日期:2015-12-29
  • 基金资助:

    国家高技术研究发展计划(863计划)资助项目(2009AA064102)

Process parameters of ammonium sulfite oxidation in ammonia desulfurization technology

 GU  Xiao-Jing, HE  Ren-Chu, WAN  Hao, FAN  Xiang-Dong   

  1. 1. School of Mechatronic Engineering and Automation, Shanghai University, Shanghai 200072, China; 2. School of Environmental and Chemical Engineering, Shanghai University, Shanghai 200444, China
  • Received:2014-05-09 Online:2015-12-29 Published:2015-12-29

PDF

501

被引次数

2

摘要： 通过改变亚硫酸铵初始浓度、硫酸铵初始浓度、反应温度、混合液pH值、空气流量、催化剂浓度, 研究氨法脱硫中亚硫酸铵氧化率的变化. 结果表明: (NH4)2SO3的浓度与 (NH4)2SO3的氧化率成反比关系; 初始 (NH4)2SO4浓度越大, (NH4)2SO3氧化率越低; 当反应温度为40~60 ℃时, 随着温度的升高,  (NH4)2SO3的氧化率不断增大;  (NH4)2SO3氧化率受混合溶液pH值的影响, 较合适的pH值为5.5; 当空气流量为100~400 L/h时, 随着空气流量的增大,  (NH4)2SO3的氧化率增大; 随着催化剂CoSO4浓度升高,  (NH4)2SO3氧化率增大.结合氨法脱硫工程实例考虑, 当反应温度控制在50 ℃ 左右, (NH4)2SO3采用低浓度氧化, 混合液pH值为5.5, 空气流量为300 L/h, 催化剂浓度较高时, (NH4)2SO3的氧化率较高.

关键词: 氨法, 亚硫酸铵, 氧化率

Abstract: The influence of affecting factors on the oxidation rate of (NH4)2SO3 including concentration of (NH4)2SO3, concentration of (NH4)2SO4, temperature, pH value, air flow rate and concentration of CoSO4 were studied. The results showed that the oxidation rate of (NH4)2SO3is lowered with the increase of initial concentration of (NH4)2SO3. It is the same as concentration of (NH4)2SO4. From 40 ℃ to 60 ℃, (NH4)2SO3 oxidation rate increases with the increase of reaction temperature. The (NH4)2SO3 oxidation rate is also influenced by the pH value of the mixed solution, with the most preferred value being 5.5. When the air flow rate is within 100~400 L/h and with increase of air flow, (NH4)2SO3 oxidation rate increases. Taking into account the ammonia desulfurization project, the most appropriate process parameters are: reaction temperature at about 50 ℃, (NH4)2SO3 at low concentration, the pH value of mixed solution at 5.5, air flow rate at 300 L/h and CoSO4 at high concentration.

Key words: ammonia method, ammonium sulfite, oxidation rate

中图分类号: 

© 2019 上海大学学报(自然科学版)编辑部
办公地址：上海市宝山区南陈路333号上海大学东区3#楼221室电话：021-66135508　 传真：021-66132736　 E-mail： xuebao@mail.shu.edu.cn
通信地址：上海市上大路99号上海大学126信箱 邮编：200444
本系统由北京玛格泰克科技发展有限公司设计开发 技术支持：support@magtech.com.cn